Franklin, TN – June 3, 2021 – Nissan (OTCMKTS:NSANY) has issued a recall for 24,140 Armada and Infiniti QX80 vehicles with faulty fuel pumps. The fuel pump issues can cause the engine to stall, increasing the risk of a crash. The recall includes:
- 2020 Nissan Armada
- 2021 Nissan Armada
- 2020 Infiniti QX80
- 2021 Infiniti QX80
The recall only includes units equipped with V8 engines. The affected part is the fuel pump module; part number A7040-3ZD0B.
Recall summary
The recall stems from an issue with the impeller similar to that seen with some 2012 Honda and Acura models, which is a disc that draws fuel from the tank and directs it to the fuel pump. As a result of a supplier error, the impeller can swell and cause the fuel pump to “bind internally.” This can disrupt the flow of fuel to the engine and result in the car stalling while driving.
There have been no incidents caused by this issue in the U.S., according to Nissan.
Risks
A fuel pump failure while driving will cause a vehicle to abruptly lose power, increasing the likelihood of being rear-ended by another vehicle.
If the system fails while the vehicle is immobile, it can prevent the engine from starting.
Warning signs and safety tips
The manufacturer says there are no warnings before a stall. However, generally speaking, a faulty fuel pump can manifest in a number of ways, such as the engine sputtering at high speeds or a drop in the gas mileage.
The “check engine” light may also come on. In case you experience any of the above signs while driving, calmly maneuver your car to the side of the road and contact roadside assistance.
Other Nissan and Infiniti recalls
Back in April, Nissan issued a recall for the 2021 Infiniti Q50 and Q60 sedans that also faced a potential stalling problem. However, that was related to a software issue and bears no connection to this recall. The Nissan Armada 2021 is not subject to any other recalls.
In September 2019, Nissan recalled several models including the 2018-2019 Nissan Armada due to Improper programming that potentially affects the back-up camera display. This recall included more than 1,200,000 automobiles.
The repair
Dealers will replace the affected fuel pump module, free of charge. Owners will be sent a letter with more information on July 20. However, it is not clear when the repairs will be performed.
No U.S. drivers had come forward with EPS-related problems. Even so, the stateside Hyundai division chose to initiate a voluntary recall March 24. Dealers were notified March 31.
The Solution
Hyundai Motor America has ordered dealers to replace defective EPS motors in affected vehicles. This particular part falls under the original factory warranty, which covers the EPS system and other components for five years or 60,000 miles. Therefore, owners should not incur expenses when taking their vehicles in for service. The automaker intends to notify affected Elantra owners via first-class mail by April 28.
Is your vehicle part of this recall?
Over 24,000 Nissan vehicles have been affected by this Nissan recall. To see if yours is one of them, use MotorSafety’s free vehicle lookup tool.
